Very effective water - based cleaner for use in hold cleaning and general digressing. its heavy molecular surfactants rapidly reacts with water and produce effective cleaning solution .May be applied by brush, hand spray and by high and low pressure cleaninng machines.
It contains wetting agents ,penetrating agents & alkaline materials with heavy molecular surfactants. non caustic tank cleaner suitable for veg oil.
For degreasing and removal of residues of mimerals oil , coal stain and soot from surface.
Procedure-of-Use:
General-Cleaning:- RXSOL-20-3002-025 is not suitable for use with Aluminum, Magnesium and Zinc Silicate coatings can be used for all types of cleaning & degreasing & may be applied by brush, hand spray, high & low pressure washing machines etc.
Tank Cleaning : For removal of residues of Minerals,Animals,Vegetable or Fish oil, Waxes & Soot from systems.
For Cargo Tanks to Remove Soot from Systems :-
1.Spray RXSOL-20-3002-025 on with a high pressure cleaning machine and use1:6 with water.If used with hand sprayer,spray the product concentrate onto the surface,allowing 1 lit. for every 10-12 m2.Use a 5-8% solution in a tank washing machine.
2.Leave for about 30-60 minutes. The surface should be kept wet.
3.Wash down with hot water (80°C) and check the cargo tank.
4.Repeat the procedure if necessary.
Refer to technical datasheet. and the Material Safety Data Sheet before use. Always refer to any warning, instructions and labels supplied with the products.
Methods-of-Application-and-Dose Rates :-
1.Injection method for tank washing machines.Dose rate 1-10 Ltrs.per ton wash water 0.11%
2.Circulation method. Dose rate 1-10 litres per ton wash water (0.1-1%).
3.Direct Spot cleaning.Handspray concentrate or diluted with up to 5 parts water & leave for several minutes
before rinsing off with clean water.
| Product Properties | |
| Appearance | Orange liquid |
| Density | In g/cm3 at 20°C: 1.06. |
| Compatibility | |
| Metal | The conc. product may react with Aluminium, Zinc, Tin & their Alloys. |
| Rubber | No known effect |
| pH | 13 |
Characteristics :-
-
Water-based cleaner. Biodegradable. Non-flammable.Free from hydrocarbon solvents. Effective & economical in use.RXSOL-20-3002-025 has numerous cleaning applications including removal of Greases, Waxes, Oil, Sludge, Soot,Carbon deposits & General dirt and Grime. Suitable for cargo tank cleaning, Particularly applicable for removing soot deposits from systems.
Read the Material Safety Data Sheet before using this product
Read the Material Safety Data Sheet before using this product
| Product Properties | |
| Appearance | Orange liquid |
| Density | In g/cm3 at 20°C: 1.06. |
| Compatibility | |
| Metal | The conc. product may react with Aluminium, Zinc, Tin & their Alloys. |
| Rubber | No known effect |
| pH | 13 |
Characteristics :-
-
Water-based cleaner. Biodegradable. Non-flammable.Free from hydrocarbon solvents. Effective & economical in use.RXSOL-20-3002-025 has numerous cleaning applications including removal of Greases, Waxes, Oil, Sludge, Soot,Carbon deposits & General dirt and Grime. Suitable for cargo tank cleaning, Particularly applicable for removing soot deposits from systems.
Read the Material Safety Data Sheet before using this product
All chemical products should be handled with care. Protective clothing and respiratory equipment should be used where necessary.
Safety Phrases
S-2 Keep out of the reach of children.
S-26 In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
S-36/37/39 Wear suitable protective clothing, gloves and eye/face protection.
S-45 In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible).
| Product Name | RXSOL-20-3002-020 |
| Product Type | RX TUFF Cleaner-I |
Company Details:
RX MARINE INTERNATIONAL
105, A wing , BSEL , TECH PARK.
VASHI ,NEW BOMBAY 400703 INDIA
| Phone | +91 22 65113333 / 5555 / 9999 / 27611360 |
| Fax | +91 22 2781 1318 :::AOH :0091 9821214367 |
| mail@rxmarine.com |
|
Chemical Name |
Concentration |
CAS Number |
EC Number |
R Phrases* |
Symbols |
|
Potassium hydroxide |
10 - 5% |
1310-58-3 |
215-181-3 |
35 |
C |
|
2-butoxy ethanol |
1 - 5% |
31800-88-1 |
203-905-0 |
41 |
X |
|
Fatty alcohol ethoxylate |
5 -10 % |
34398-01-1 |
500-084-3 |
34 |
|
| Mixture of Surfactant - Cationic | 3 - 4 % |
68989-03-7 |
Mix Blend | 36 | |
|
Metasilicate |
4 - 5% |
6834-92-0 |
229-912-9 |
37 | |
|
Non classified ingredients |
60-70 |
|
|
|
|
Corrosive
|
Odour |
Odourless |
|
Appearance |
Liquid, colourless , soluble in water |
|
Contact with eyes |
Corrosive to eyes, Can cause damage to the eyes |
|
Contact with skin |
Causes severe burns (R35) |
|
Inhalation |
No information available but must be considered harmful |
|
Ingestion |
Harmful if swallowed (R22) |
|
Contact with skin |
Remove contaminated clothing immediately and drench affected skin with plenty of water. Then wash with soap and water Seek medical advice if necessary |
|
Contact with eyes |
If substance has got into eyes, immediately wash out with plenty of water for at least 15 minutes Irrigate eyes thoroughly whilst lifting eyelids Obtain immediate medical attention Continue flushing with water until medical help arrives |
|
Ingestion |
Do not induce vomiting Never give anything by mouth to an unconscious person Give water or milk to drink Obtain immediate medical attention |
|
Inhalation |
Seek medical attention if ill effects occur In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible) (S45)When in doubt or symptoms persist, seek medical attention |
- Non combustible
- Smoke from fires is corrosive
- Not flammable. In case of fire use extinguishing media appropriate to surrounding conditions
- Vapour density - not applicable
|
Personal Precautions |
Wear protective clothing as per section 8 |
|
Environmental Precautions |
Do not allow to enter public sewers and watercourses |
|
Clean Up Actions |
Absorb spillage in inert material and shovel up Ventilate the area and wash spill site after material pick-up is complete Neutralise with Acid |
|
Special Precautions |
Wear protective clothing as per section 8 |
|
Handling |
Eyewash bottles should be available See Section 8 |
|
Storage |
Keep only in the original container in a cool, well ventilated place (S3/9/49) Protect from frost |
|
Exposure Limits |
OES / LTEL # ppm 2 mg/m3 (Sodium hydroxide) |
|
Exposure controls |
No special ventilation is required unless the product is used in a spray form |
|
Occupational exposure controls |
Wear suitable protective clothing, including eye/face protection and gloves (plastic or rubber are recommended) During fumigation/spraying wear suitable respiratory equipment (S42) |
Gloves Suit Goggles No_Smoking
|
Odour |
Odourless |
|
Appearance |
Liquid, colourless to yellow, soluble in water |
|
pH |
11.5 - 12.5 at 0.1 % concentration, pH 13 - 14 at 100 % concentration |
|
Boiling point |
>100 °C at 760 mm /Hg |
|
Vapour pressure |
not known |
|
Vapour density |
not applicable |
|
Freezing point |
5 °C at 760 mm/Hg |
|
Completely soluble in water |
|
|
Specific gravity (water=1) |
1.23 |
|
Non combustible |
|
- This article is considered stable under normal conditions
- Avoid overheating, Keep away from frost
- Incompatible with acid
- See Section 5
|
Toxicological information |
No experimental data available |
|
Inhalation |
Can cause damage to the respiratory system |
|
Contact with skin |
Causes severe burns (R35) |
|
Contact with eyes |
Causes severe burns (R35) |
|
Ingestion |
The ingestion of significant quantities may cause burning sensation |
|
Carcinogenicity |
No evidence of carcinogenic effects |
|
Ecotoxicity |
This product has been evaluated on its behaviour in the environment by"The TNO Institue of Environmental Sciences" (The Netherlands organisation for applied Scientific Research).Their conclusion on this product reads: "In general, this cleaning agent poses little danger to the environment,its main ingredients will either dissolve rapidly and dissociate in water or are readily/inherently biodegrada ble." Based upon their report, IMO's BCH Working Group on the Evaluation of Safety and Pollution Hazards approved this product for use as tank cleaning agent by chemical tankers. |
|
Mobility |
Completely soluble in water |
|
Persistence and Biodegradability |
Its main ingredients will either dissolve rapidly and dissociate in water or are readily / inherently biodegradable. |
|
Bioaccumulation Potential |
Bioaccumulation of the components in this product is insignificant. |
|
Other Adverse Effects |
May cause acute effects in the environment No environmental problems are expected when the product is used / handled correctly. In its intended use, the product will not be released into the environment. |
|
Classification |
This material and/or its container must be disposed of as hazardous waste EU Waste class: 06 02 02 |
|
Disposal considerations |
Do not discharge into drains or the environment,dispose to an authorised waste collection point Disposal should be in accordance with local, state or national legislation |
| Proper Shipping Name | SODIUM HYDROXIDE, SOLUTION | |||
| UN | ||||
| Proper Shipping Name | Potassium hydroxide, solution | |||
| UN NO. | 1824 | |||
| Hazard Class | 8 | Packing Group | II | |
| Road/Rail (ADR/RID) | ||||
| Proper Shipping Name | Potassium hydroxide, solution | |||
| ADR UN No. | 1824 | |||
| ADR Hazard Class | 8 | Termcard | 80S1824 | |
| Sear (IMDG) | ||||
| Proper Shipping Name | Potassium hydroxide, solution | |||
| IMDG UN No. | 1824 | |||
| IMDG Hazard Class | 8 | IMDG Pack Group | II | |
| IMDG EmS | F-A, S-B | IMDG subrisk | NA | |
| IMDG Labels | 8 | IMDG Flashpoint | N/A | |
| Air(ICAO/IATA) | ||||
| Proper Shipping Name | Potassium hydroxide, solution | |||
| ICAO UnNo. | 1824 | |||
| ICAO HazardClass. | 8 | ICAO PackingGroup. | II | |
| ICAO subrisk |
N/A |
ICAO Labels | 8, CAO | |
| ICAO Flashpoint |
N/A |
|||
| DOT/CFR(USDepartment ofTransportation | ||||
| DOTProperShippingName | Potassium hydroxide, solution | |||
| HazardousMaterial | Potassium hydroxide | |||
| Hazard Class | 8 | IdentificationNumber | ||
| Product RQ (lbs) | 3640 | DOTsubrisk |
N/A |
|
| DOTLabels | 8 | DOTFlashpoint | N/A | |
- Forbidden on passenger aircraft
|
Risk Phrases |
Causes severe burns (R35) |
|
Safety Phrases |
In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. Wear suitable protective clothing, eye/face protection. In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible). |
|
Text of R and S phrase codes used in this safety data sheet:- R34: Causes burns; R37: Irritating to respiratory system.The information provided about the product on this Safety Data Sheet has been compiled from knowledge of the individual constituents The data given here is based on current knowledge and experience. This Safety Data Sheet describes the product in terms of safety requirements and does not signify any warranty with regard to the product's properties The data given here only applies when product used for proper application(s). The product is not sold as suitable for other applications-usage in such may cause risks not mentioned in this sheet. Do not use for other application(s) without seeking advice from manufacturer DISCLAIMER OF LIABILITY :The information in this SDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the product. This MSDS was prepared and is to be used only for this product. If the product is used as a component in another product, this MSDS information may not be applicable. |