Air Cooler Chemical ACC-009 RXSOL-16-1049-020 is a concentrated solvent emulsion cleaner for cleaning of Air coolers, Scavenging air systems and turbochargers of the diesel engine.
In-service cleaning–RXSOL-16-1049-020 Air Cooler Chemical ACC-009is passing through the air trunking upstream of the charge air cooler, followed by a clean water rinse.For cleaning of air coolers, it is necessary to use correctly installed dosing and injection system.
Hand spray Cleaning:-
By Hand spray, apply concentrate RXSOL-16-1049-020 all over the cooler coils. for good emulsification & penetration. Allow the RXSOL-16-1049-020 for a minimum of 1 hour, then use a high pressure water to wash off the loosened deposits. During process always keep drain valve open. After satisfactory cleaning, and flushing through with fresh water, close air cooler drains.Note that during this process the engine must be stopped.
Soak method :
Machine parts with stubborn carbon deposits to be cleaned is dipped into conc. Soln.of ACC then allow deposits too. Be broken down and loosened before removal, then rinse.
3 to 5 litres of cleaning solution per square meter or as table below:
| Engine HP. | Solution of 10 to 25% RXSOL-16-1049-020 |
| 6,000 to 12,000 | 2 to 3 litre |
| 12,000 to 24,000 | 4 to 5 litre |
| 24,000 or more | 6 litre |
NOTE :
For cleaning of Air cooler and Air side of turbochargers, a solution of 5 - 25% RXSOL-16-0009-ACC in fresh water is recommended. Inject the solution for 10-15minutes, then similar quantity of fresh water injected to rinse off emulsifieddeposits.
Characteristics:
-
Formulated to remove oil, grease & carbon deposits from air coolers & scavenging system
- Efficient and economical.
- May be used for in-service cleaning.
- Renders surfaces oil-repellent.
- Maintains and stabilizes air cooler efficiency at a maximum.
- Saves time, maintenance costs and avoids risks of damage when dismantling.
- Leaves no residue and has no harmful effect on the engine.
- Product in water solution is non-flammable, non-explosive and has no flash point.
- Can be used for light carbon removal from machinery parts
**Read the Material Safety Data Sheet before using this product**
TRIPLE ACTION OF ACC9 Air Cooler Cleaner :::
ACC9 is industrial equipment maintenance air cooler cleaner for cleaning of the diesel engine charge Air cooler. ACC9 is Light yellow to brown colored water-soluble solvent, which emulsifies with water. ACC9 is blend of the selected specified solvent mixture which is safe in contact with all metals.
ACC-9 Air Cooler Cleaner Principally works as follows, with Triple Action :
1st Action : Non Corrosive Solvent present in ACC9 helps to dissolve all deposits, oil, greasy materials.
2ndly : While emulsifier increases Detergency property to enhance cleaning action of ACC-9.
3rd Important feature of ACC-9 the presence of inhibitors in ACC9 protect soft metal, we can say INHIBITOR makes solution safe to contact with all metals.
This is the reason, why ACC9 is VERY Popular.
| Product Name | RXSOL-16-1049-020 |
| Product Type | AIR COOLER CLEANER-Lt Air Cooler Chemical ACC-009 |
Company Details:
RX MARINE INTERNATIONAL
105, A wing , BSEL , TECH PARK.
VASHI ,NEW BOMBAY 400703 INDIA
| Phone | +91 22 65113333 / 5555 / 9999 / 27611360 |
| Fax | +91 22 2781 1318 :::AOH :0091 9821214367 |
| mail@rxmarine.com |
|
Chemical Name |
Concentration |
CAS Number |
Symbols |
|
Destillate(petroleum)Hydrotreated |
10-30 |
64742-47-8 |
Xn |
|
Fatty Alcohol Ethoxylate |
10-30 |
34398-01-1 |
Xi |
| DICHLOROTOLUENE | >=50-60% | 29797-40-8 | Xn |
|
2, 2 (Butoxyethoxy) Ethanol |
5-10 |
112-34-5 |
Xi |
| DIESEL FUEL | >=30-40% | 68476-34-6 | Xn |
|
2-Ethylhexanolethoxylate |
1-5 |
26468-86-0 |
Xi |
| O-CHLOROTOLUENE | >=10-15% | 95-49-8 | Xn |
| COCONUT OIL DIETHANOLAMIDE | >=5-10% | 8051-30-7 | Xi |
| 4-CHLOROTOLUENE | >=1.5-5% | 106-43-4 | Xn |
| NAPHTHALENE | >=0.1-0.5% | 91-20-3 | Xn |
*See Section 16
|
Odour |
Solvent odour |
|
Appearance |
Liquid, pale yellow, soluble in water |
|
Contact with eyes |
Risk of serious damage to eyes (R41) |
|
Contact with skin |
Causes irritation, Prolonged skin contact will result in defatting of the skin, leading to irritation, and in some cases, dermatitis |
|
Inhalation |
Vapours or aerosols may cause irritation of eyes, nose and respiratory tract, In cases of severe exposure, shortness of breath may develop |
|
Ingestion |
Harmful: may cause lung damage if swallowed (R65) |
|
Contact with skin |
Remove contaminated clothing immediately and drench affected skin with plenty of water. Then wash with soap and water Seek medical attention if irritation persists |
|
Contact with eyes |
If substance has got into eyes, immediately wash out with plenty of water for at least 15 minutes Irrigate eyes thoroughly whilst lifting eyelids When in doubt or symptoms persist, seek medical attention |
|
Ingestion |
Do not induce vomiting Never give anything by mouth to an unconscious person Give water or milk to drink |
|
Inhalation |
Keep warm and at rest, in a half upright position. Loosen clothing |
|
General |
When in doubt or symptoms persist, seek medical attention Use good personal hygiene practices |
- Non-flammable
- May give off noxious and toxic fumes in a fire
- Not flammable. In case of fire use extinguishing media appropriate to surrounding conditions
|
Personal Precautions |
Wear protective clothing as per section 8 |
|
Environmental Precautions |
Do not flush spilt material into any public water system |
|
Immediate Actions |
Use appropriate containment to avoid environmental contamination (S57) |
|
Clean Up Actions |
Absorb spillage in inert material and shovel up Ventilate the area and wash spill site after material pick-up is complete |
|
Special Precautions |
Wear protective clothing as per section 8 |
|
Handling |
Use good personal hygiene practices Avoid contact with skin and eyes (S24/25) Eyewash bottles should be available |
|
Storage |
Keep only in the original container in a cool, well ventilated place (S3/9/49) |
|
Exposure Limits |
No exposure limits have been set for this substance |
|
Exposure controls |
No special ventilation is required unless the product is used in a spray form |
|
Occupational exposure controls |
Wear goggles giving complete eye protection Wear plastic or rubber gloves Wear apron No respiratory protection is required unless subject to contact with substance mist. |
- Odour: Solvent odour
- Appearance: Liquid, pale yellow, soluble in water
- pH 9.3 - 10.3 at 100 % concentration
- Boiling point ~ (>)365 °F / 185 °C at 760 mm /Hg
- Vapour pressure - 3.000 hPa @ 122 °F / 50 °C Calculated Vapor Pressure
- Vapour density - (>)1 AIR=1
- Completely soluble in water
- Density (+/- 0.01) 1.030 g/cm3 @ 77.00 °F / 25.00 °C
- Flash point 155.98 °F / 68.88 °C Tag open cup
- Evapouration rate (>)1 Ethyl Ether
- Thisarticleisconsideredstableundernormal conditions
- Avoidoverheating, Keepawayfromfrost
- Decompositionproductsmayincludecarbonoxides
|
Toxicological information |
No experimental data available. |
|
Inhalation |
By comparison with analogous substances, it is concluded that it may be harmful. |
|
Contact with skin |
May cause redness and irritation. |
|
Contact with eyes |
May cause severe irritation. |
|
Ingestion |
The ingestion of significant quantities may cause damage to lungs. |
|
Carcinogenicity |
No evidence of carcinogenic effects. |
|
Mobility |
Completely soluble in water |
|
Persistence and Biodegradability |
The components in this product are readily biodegradable. |
|
Bioaccumulation Potential |
Bioaccumulation of the components in this product is insignificant. |
|
Other Adverse Effects |
No environmental problems are expected when the product is used / handled correctly. |
|
Classification |
This material and/or its container must be disposed of as hazardous waste EU Waste class: 07.01 |
|
Disposal considerations |
Do not discharge into drains or the environment, dispose to an authorised waste collection point |
• Marine pollutant: No
• Transport/Additional information : Not dangerous .
DOT/TDG Land transport (ADR): NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS
| UN Number | Not Applicable |
| Proper shipping name | Noit Applicable |
| Hazard Class | Not Applicable |
| Packing group | Not Applicable |
| Special Provision | Not Applicable |
| Limited Quantity | Not Applicable |
Air transport (ICAO-IATA / DGR): NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS
| UN Number | Not Applicable |
| Proper shipping name | Noit Applicable |
| ICAO/IATA Hazard Class | Not Applicable |
| ICAO/IATA Packing group | Not Applicable |
| ICAO/IATASpecial Provision | Not Applicable |
| ICAO/IATA Limited Quantity | Not Applicable |
IMDG/IMO Sea transport (IMDG-Code / GGVSee): NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS
| UN Number | Not Applicable |
| Proper shipping name | Noit Applicable |
| IMDG Hazard Class | Not Applicable |
| IMDG Packing group | Not Applicable |
| IMDG Special Provision | Not Applicable |
| IMDG Limited Quantity | Not Applicable |
Transport in bulk according to Annex II of MARPOL and the IBC code : Not Applicable.
- Repeated exposure may cause skin dryness or cracking (R66)
- Risk of serious damage to eyes (R41)
Safety Phrases :
- Do not breathe spray/mists (S23)
- In case of contact with eyes, rinse immediately with plenty of water and seek medical advice (S26)
- If swallowed, do not induce vomiting: seek medical advice immediately and show this container or label (S62)
- Wear suitable protective clothing, eye/face protection and gloves (S36/37/39)
Text of R and S p hrase codes used in this safety data sheet:- R36: Irritating to eyes; R41: Risk of serious damage to eyes:R65: Harmful: may cause lung damage if swallowed; R66: Repeated exposure may cause skin dryness or crac- king.The information provided about the product on this Safety Data Sheet has been compiled from knowledge of the individual constituents The data given here is based on current knowledge and experience.This Safety Data Sheet describes the product in terms of safety requirements and does not signify any warranty with regard to the product's properties The data given here only applies when product used for proper application(s).The product is not sold as suitable for other applications - usage in such may cause risks not mentioned in this sheet. Do not use for other application(s) without seeking advice from manufacturer Composition information in accordance with Regulation (EC) No 648/2004 of the European Parliament and of the Council of 31 March 2004 on detergents
| Aliphatic hydrocarbons | 15-30 % |
| Anionic surfactants | 15-30 % |
| Amphitricha surfactants | 5 % |
DISCLAIMER OF LIABILITY :The information in this SDS was obtained from sources which we believe are reliable. However, the information is provided without any warranty, express or implied, regarding its correctness. The conditions or methods of handling, storage, use or disposal of the product are beyond our control and may be beyond our knowledge. For this and other reasons, we do not assume responsibility and expressly disclaim liability for loss, damage or expense arising out of or in any way connected with the handling, storage, use or disposal of the product. This MSDS was prepared and is to be used only for this product. If the product is used as a component in another product, this MSDS information may not be applicable.
|
41 |
|
41 |